I went to remove my transmission oil filter (the cigarette looking filter) and looked in the hole and there was only a small clump of metal. What happened to my transmission oil filter? I tipped quad on its side and started shaking the quad and metal shavings started coming out with left over transmission oil. anyone ever heard of this? My transmission oil filter was not in the greatest condition when inserting it (slightly bent).
After looking at the size of clump of metal and metal that fell out, I am pretty sure there is more of the chewed up filter inside. How do i get the remaining pieces of the filter out? Put in some oil and let in drain out, and maybe it will carry out the remaining pieces?
thanks
Engine chewed up my transmission oil filter
-
- Posts: 0
- Joined: Wed Mar 10, 2021 10:41 pm
Filter fix
This is more common than you think.Filter design has been a problem right from start.I am afraid the onlysure way of getting everything out is to pull the motor an remove the tranny and clean everything.There is a spray bar that has very small holes that will plug up and a oil pump that could be damaged.
I have come up with a solution I think how about this:
I have come up with a solution I think how about this:
Anything that will keep the filter attached to the drain plug would be good. When i screwed in my trans oil drain plug, i was sure the filter was attached securely into the hole of the drain bolt. I could easily screw in by hand. Somehow the filter became unattached from the drain bolt and now the filter is a clump of metal.
I had the same thing happen to me a month ago. I just took the bottom frame rail off so you can get a straight shot at looking in the drain hole and you can see all the pieces. Then I ran 2 gallons of diesel fuel thru it to drain it out. Then new oil and filter, ran it for 1/2 hour and changed the oil. I have not had any problems since.
I did not pull the engine but I ran it for 3 straight days in the dunes and it ran great. The diesel got alot of little shavings out and it is alot cheaper than buying oil. I had about 5 or 6 pieces of filter left when I got it all out. I could not get them all out until I took off the bottom frame rail.